Self-Compacting Concrete with Partially Substitution of …
Self-compacting concrete (SCC) is also seen as unsustainable since it uses a lot of natural resources. Recent researchers have focused on lowering construction costs and partially replacing cement with industrial waste. It is possible to effectively use various industrial wastes in concrete as cement or aggregates. Among these wastes, waste marble (WM) is a …
اقرأ أكثر
A Review on Performance of Self-Compacting Concrete
The investigation on mechanical properties of Filling Layer Self-Compacting Concrete (FLSCC) was performed. Results indicated that cyclic load and freeze coupling …
اقرأ أكثر
(PDF) High-strength Self-compacting Concrete
The mix quantity for 1m3 concrete was 315 kg Class F fly ash, 315 kg OPC, 630 kg quarry dust, 508 kg river sand, 400 kg coarse aggregate, 0.7% superplasticizer,0.32 % w/b, 0.10% macro fiber ...
اقرأ أكثر
A Review on Performance of Self-Compacting Concrete
Self-compacting concrete ... sand, partial cement replacement in form of fly-ash (FA), partial sand replacement in form of bottom ash, water/powder and water ratio, the dosage of super-plasticizer. ... The research studied the usage of quarry limestone fines from crushed sand (manufactured) on its mechanical, durability, and rheological ...
اقرأ أكثر
Experimental Investigation on Self Compacting …
Quarry Dust to be used as partial replacement materials for sand in SCC. Index Terms — SCC, Fly Ash, Silica Fume, Quarry Dust, Super II.plasticizer, compressive strength, split tensile strength. I. INTRODUCTION elf-compacting concrete (SCC) is considered as a concrete which can be placed and compacted under its self weight
اقرأ أكثر
SELF COMPACTING CONCRETE WITH QUARRY DUST …
Self compacting concrete is a concrete which can be placed and compacted under its self weight with no vibration effort. It has high workability that it can flow under its own weight.
اقرأ أكثر
Use of Limestone Quarry By-Products for Developing Economical Self
Changes in material cost and strength of SCC are compared in this section. Partial Replacement of Sand with Quarry Fines As shown in Table 38 and Fig. 12, replacement of up to 50% of natural sand with quarry fines lowered the material cost of self-compacting concrete slightly and did not affect the strength of the concrete significantly.
اقرأ أكثر
A Review on Self Compacting Concrete
The object of this research work is to study the effect of using recycled glass waste, as a partial replacement of fine aggregate, on the fresh and hardened properties of Self-Compacting...
اقرأ أكثر
Water Absorption and Compressive Strength of Self …
The objective of this study is to determine workability (filling ability and passing ability) of self-compacting concrete incorporating quarry dust and fly ash using the slump flow test and the j-ring test. Moreover to determine the water absorption and compressive strength performance of self-compacting concrete incorporating quarry dust at ...
اقرأ أكثر
Study of self compacting concrete with partial replacement …
The present experiment is carried out to investigate the fresh and hardened properties of Self Compacting Concrete with 50 percentage of quarry dust as a …
اقرأ أكثر
Effect of Partial Replacement of Cement by Metakaolin on …
To fulfill this construction demand, a large amount of concrete is required. Concrete is a mixture of cement, sand, coarse aggregate, water, and different additives. In this study, the potential of metakaolin as a partial replacement for cement in concrete was investigated.
اقرأ أكثر
Mechanical Propertıes of Concrete with Partial Replacement …
The results of the study showed that quarry rock dust can be used as a substitute for natural sand in concrete, with fly ash as a partial replacement for cement. The concrete made with quarry rock dust and fly ash had comparable or improved physical, mechanical, and durability properties compared to natural sand concrete.
اقرأ أكثر
Experimental Investigation on Self Compacting Concrete Using Quarry Dust
This study presents an experimental investigation on self-compacting concrete (SCC) with fine aggregate (sand) replacement of a Quarry Dust (QD) (0%, 25%, 50%, 75%, ) and addition of mineral admixtures like Fly Ash (FA) and Silica Fume (SF) & chemical admixtures like super plasticizers (SP).
اقرأ أكثر
IRJET- A REVIEW ON INFLUENCE OF QUARRY …
The results indicated that the incorporation of quarry dust into the self compacting Concrete mix as partial replacement material to natural sand resulted in higher compressive strength and optimization of sand …
اقرأ أكثر
Mock-up pragmatic study on the impact performance of self …
Self-Compacting Concrete (SCC) allows for the use of non-desalted sea sand as a fine aggregate, but the durability of triple mix SCC with partial sea sand replacement …
اقرأ أكثر
Compressive Strength by Incorporating Quarry Dust in …
strength of the quarry dust modified self-compacting concrete shows the trend of higher compressive strength up to 30% addition of quarry dust with sand replacement and further …
اقرأ أكثر
A comprehensive review of partial replacement of cement in concrete
In terms of strength development, rice husk ash concrete is like fly ash/slag concrete. Rice husk ash, on the other hand, is a very active pozzolanic material, and the consequences of the pozzolanic reactions are visible at an early age rather than later as with other replacement cementing materials [14].It is favorable to the strength development of …
اقرأ أكثر
Influence of sustainable materials in strength and durability of self …
Venkatesh et al., reported 9.86, 14.19 and 7.54% improvement in compressive strength, tensile strength and flexural strength respectively when 5% of crumb rubber and 10% of foundry sand were used in self-compacting concrete. 5% of crumb rubber can be taken as an optimum percentage for fine aggregate replacement in self-compacting concrete.
اقرأ أكثر
Experimental Investigation on Self Compacting …
Compacting Concrete by Partial Replacement ... self compacting concrete (SCC), quarry dust, ... 60% replacement of sand by quarry dust without plasticizer and 70% - 80% replacement with ...
اقرأ أكثر
Experimental Investigation on Self Compacting Concrete Using Quarry Dust
Optimization of stone dust and fly ash is also obtained. The results indicated that the incorporation of quarry dust into the self compacting Concrete mix as partial replacement material to natural sand resulted in higher compressive strength and optimization of sand replacement is 40%.
اقرأ أكثر
Experimental Studies on Self Compacting Concrete by …
Our main aim is to determine the effect of combination of rice husk ash and bagasse ash as partial substitute of cement on the properties of self-compacting concrete in fresh state …
اقرأ أكثر
Experimental Investigation on Self Compacting Concrete Using Quarry Dust
This study presents an experimental investigation on self-compacting concrete (SCC) with fine aggregate (sand) replacement of a Quarry Dust (QD) (0%, 25%, 50%, 75%, ) and addition of mineral admixtures like Fly Ash (FA) and Silica Fume (SF) & chemical admixtures like super plasticizers (SP). After each mix preparation, 45 cubes specimens and 45 cylinders specimens …
اقرأ أكثر
Fresh properties of self-compacting concrete with plastic …
For this purpose, different self-compacting concrete mixes were designed at ... using cement partially replaced with 5%, 10%, 15% and 20% pulverized fuel ash, carbide waste and quarry dust. ... Original Article/Research Fresh properties of self-compacting concrete with plastic waste as partial replacement of sand Sheelan M ...
اقرأ أكثر
STRENGTH AND DURABILITY ASSESSMENTS OF …
crushing strength of self-compacting concrete at an early age. Total replacement of sand with quarry dust in generally-known concrete enhances its crushing strength [12]. Study showed that using quarry dust in high performance self-compacting concrete can assist in eradicating the challenge of alkali silica reaction [13].
اقرأ أكثر
A Review on Self Compacting Concrete
In order to conserve natural sand, quarry dust (QD) as a waste and sustainable material has been incorporated to replace fine aggregate in SCC. ... conventional concrete and quarry dust in self ...
اقرأ أكثر
SELF COMPACTING CONCRETE WITH QUARRY DUST AS PARTIAL REPLACEMENT …
International Research Journal of Engineering and Technology (IRJET) e-ISSN: 2395 -0056 Volume: 04 Issue: 05 | May -2017 p-ISSN: 2395-0072 SELF COMPACTING CONCRETE WITH QUARRY DUST AS PARTIAL REPLACEMENT FOR FINE AGGREGATE AND FLYASH FOR CEMENT WITH FIBRE REINFORCEMENT V. Anish1, Dr. G. …
اقرأ أكثر
QUARRY ROCK DUST AS A PARTIAL REPLACEMENT OF NATURAL SAND IN …
In this paper Quarry Dust (QD) is used as partial replacement for River Sand (RS) to make Self Compacting Concrete (SCC) of grade M40. Glass fiber is used as strengthening material to the ...
اقرأ أكثر
Replacement of river sand by crusher dust in self compacting concrete
The studies indicate that the hardened properties of SCC with crusher dust replacement are improved and crusher dust has a good potential as fine aggregate in the production of Self Compacting ...
اقرأ أكثر
Behaviour of self-compacting concrete with manufacturing sand …
This study presents an experimental investigation on self-compacting concrete (SCC) with fine aggregate (sand) replacement of a Quarry Dust (QD) (0%, 25%, 50%, 75%, ) and addition of mineral ...
اقرأ أكثر
Study on Effect of Self-Compacting Concrete with Partial …
ABSTRACT:- This study presents an experimental investigation on self compacting concrete (SCC) with various partial replacements of fly ash, silica fume and combination of both fly …
اقرأ أكثر